Development and verification of a reporter gene determination assay for ADCP potency of IgG2 anti-EGFR monoclonal antibody based on DOE
10.13200/j.cnki.cjb.004269
- VernacularTitle:噬作用生物学活性报告基因检测法的建立及验证
- Author:
ZHAO Qin
- Publication Type:Journal Article
- Keywords:
IgG2;
Epidermal growth factor receptor(EGFR);
Monoclonal antibody(mAb);
Antibody dependent cellular phagocytosis(ADCP);
Biological potency;
Reporter gene assay;
Design of Experiments(DOE);
One factor at a time(OFAT)
- From:
Chinese Journal of Biologicals
2024;37(07):859-865
- CountryChina
- Language:Chinese
-
Abstract:
Objective To develop and verify a reporter gene assay for the determination of antibody dependent cellular phagocytosis(ADCP)potency of Ig G2 monoclonal antibody(m Ab)against epidermal growth factor receptor(EGFR)by combining Design of Experiment(DOE)and one factor at a time(OFAT).Methods The Jurkat/NFAT-Re/FcγRⅡa stably transformed cell line was used as effector cells,while the A431 cell line as the target cells.The JMP software was used to optimize the seven key factors in the experiment by combining DOE and OFAT analysis,while the ratio of upper and lower asymptotes(D/A)was used as the statistic,and the reporter gene method was developed to evaluate the ADCP potency of Ig G2 anti-EGFR m Ab.The method was verified according to the general chapter<9401>of Chinese Pharmaco-poeia（Ⅲ/Ⅳvolume,2020 edition)and used to determine the biological potency of Ig G2 anti-EGFR m Ab injection.Results After three rounds of experiments,the reporter gene method to evaluate the ADCP potency of Ig G2 anti-EGFR m Ab was developed.The method showed a dose-response relationship and was consistent with the four-parameter regression equa-tion y=(A-D）/[1+(x/C)~B]+D.The range of seven key conditions was determined:the density of effector cells was(1.25-3.75）×10~4 cells/well,the density ratio of effector cells to target cells was 1.0-2.0,the incubation time of target cells was 20-40 min,the incubation time of administration was 15-30 min,the total time was 5.5-6.5 h,and the color time was 5-30 min with luciferase detection system(Bright-Glo)as the color agent.The method had good specificity.Six independent tests were run for the five potency levels,with the correlation coefficient r of 0.994 5 and the linear regression equation slope of 1.02.The relative potency of five potency levels respectively was(62.15±1.38)%,(78.53±2.82)%,(99.12±3.95)%,(123.27±4.59)%and(155.22±7.04)%,the range of relative biases was-2.9%-0.2%,and the range of generalized cross-validation(GCV)was 2.2%-4.6%.The method had good linearity,relative accuracy and precision in the range of 64%-156%.The mean value of the potency of IgG2 anti-EGFR m Ab in three tests was(101.5±2.8)%.Conclusion The reporter gene assay developed in this study can be used to evaluate the ADCP potency of IgG2 anti-EGFR mAb
